THE CALEDONIAN DISTILLERY, EDINBURGH.

PROPRIETORS, THE DISTILLERS' COMPANY, LIMITED.

Registered Office : 12, TORPICHEN STREET, EDINBURGH.

Secretary: E. F. DUDGEON.

OUR tour in the north, which had been such a source of pleasure to us, was now virtually at an end, and we left Stirling with same feeling of regret. The journey to Edinburgh was short when compared with the distances we had traversed. Recently our " spiritual wanderings" had been among the heather, valley, and mountain ; we were now again to visit city distilleries of such magnitude that a dozen of those lately described could be crowded into one of these establishments. It was a lovely day, and as we approached the noble and ancient metropolis of Scotland, the hills in the back-ground revealed to us a combination of glories now wreathed in green-clad garments-anon rugged and broken, some- times lifting their heads to the clouds with a sombre reverence, at others shaded by still higher crags in a mass of ever-changing witchery-and later on as we drove along Princes Street, and noted the scenic groupings of monuments, the stately Castle, and noble surroundings of this city of tragedy and romance, we were thrilled with wonder and delight, and called to mind some lines we had seen:

" Grand auld city, decked in splendour,
On the rocky heights that rise,
Scotia's guardian and defender,
Tow'ring upwards to the skies.
Fair Edina-fair remain !
Scotia's proud auld darling mither;
Where 's a street to match our ain
Princes Street in sunny weather ? "

On the morning after our arrival we paid a visit to the Caledonian Distillery. It is situated at the west end of the city, and in a neighbourhood sacred to the memory of Sir Walter Scott, who lived for many years on the estate of Dalry Manor, six hundred yards from the Distillery. Sir Walter Scott was born in Edinburgh, where he received bis instruction and learning, but the belief part of his education was gathered here and there through all Scotland-in huts and halls, from ancient battle fields, Highland chieftains, Border reevers, and the rudest ballads-no mind ever fed on more varied elements or turned them to better use. Dalry Road, where he last resided with his daughter, is in close proximity to the Distillery, and the whole locality is full of interesting reminiscences of this great man.

From the main road we diverged down a turning in close proximity to the Haymarket Station, at the end of which the whole pile of buildings connected with the works stretched out before us. Arriving at the gateway, after producing our credentials, we were admitted within.

The Caledonian Distillery covers 7 1/4 acres of ground, and was built in the year 1855 by Messrs. Menzies & Co., who transferred it to the Distiller' Company, Limited, in the year 1884- lt is the second largest Grain Distillery m the United Kingdom, and in all respects it may be called the model Distillery of Europe, as It contains every improvement of machinery and new patent known in distilling, and fully justifies this appellation. It bas also the advantage of two lines of railway right through the works (the Caledonian and the North British). The grain is delivered in bulk-covered waggons with sluice flap bottoms (the only ones of the kind we have seen in Scotland), each holding 50 quarters of grain. Arriving at the gram department the attendant unbolts the trap, and the grain falls into a sluice in the middle of the six-foot war into a continuous screw which almost in an instant sends it to the elevators (50 feet distant) carrying it up to the top floors, and delivering it by the screws, to the various grain departments-thus al most doing away with manual labour. These screws are wonderful contrivances, and consist of an endless screw the shape of a corkscrew with steel flanges, which is enclosed in a box, or trough, a foot square. The end of the screw is turned by steam power, and as the grain descends into the machinery it is screwed away any distance, and stopped in its onward progress by a very simple contrivance, at any floor or department required.

There are fourteen Grain Stores holding together over 15,000 quarters of grain, and we noticed that same of the barns were so full th at the doors had burst open with the weight. The divisional departments of the Grain Stores where the tackle goes through, and the fans for steam drying are concerned, are six in number-enormous buildings covering three acres of ground. One of them, a new lofty Gothic structure, is a notable object from the railway as you approach the Haymarket Station. Most of these Warehouses are two and three- deckers, having hydraulic lifts. No. I Warehouse contained 8,000 casks of Whisky, and No. 2 about 10,000.

At the extreme end of the works is the Malting Department, the Main Barley Loft being connected with the Grain Department by an outside gallery. It is a lofty building 172 feet long by 76 feet broad, and contains 3,000 quarters of barley, which is delivered by the screws into the two Steeps, 34 feet square and 3 1/2 feet deep, each holding 100 quarters. The grain raIls from the steeps above into the couch below, and is distributed by manual labour over the seven Malt Barns, mostly 172 feet long by 76 feet broad. There are two Malt Deposits, each holding 3,000 quarters. The two Malt Kilns are 110 feet long by 52 feet wide, and are capable of drying 900 quarters of malt weekly. Our guide then conducted us to the Still House, a fine building containing three Pot Stills. 16,000, 9,000, and 5,000 gallons content respectively, four Feints Receivers, also a large Carter's Rectifying Still capable of holding 4,000 gallons, from which the spirit runs through a patent safe at the rate of 200 gallons per hour.

The steam power is on an extensive scale in this establishment, there being seven powerful engines from 10 to 150 horse power, and eleven boilers each 30 feet long, and 71 feet in diameter.

The Cooperage is a large department, and the ground in front reminded us of the Burton Breweries, for there are many thousands of casks waiting their turns to be filled. There is a smiths', joiners' and coppersmiths' shop, together with buildings for general stores, also saw-mills and hydraulic pumps.

The water used comes from the Union Canal, and is of fine quality. The make is Grain Whisky, and the annual output of the Distillery is a little over 2,000,000 gallons.

There are 220 persons employed in the Establishment, and eleven Excise gentlemen on the premises, the chief being Mr. Halley.

The works are close to the Haymarket Station, and would amply repay the tourist a visit.

" Edina! Scotia's darling seat !
All hail thy palaces and tow'rs,
Where once beneath a monarch's feet
sat Legislation's sov'reign pow'rs !
From marking wildly-scatter'd flow'rs,
As on the banks of Ayr I stray'd,
And singing, lone, the ling'ring hours,
I shelter in thy honour'd shade.

" There, watching high the least alarms,
Thy rough, tude fortress gleams afar ;
Like same bold vet'ran, grey in arms,
And mark'd with many a seamy scar ;
The pond'rous wall and massy bar,
Grim-rising o'er the rugged rock;
Have oft withstood assailing war,
And oft repell'd th'invader's shock.

" With awe-struck thought and pitying tears,
I view that noble, stately dame,
Where Scotia's kings of other years,
Fam'd heroes! had their royal home:
Alas, how chang'd the times to come !
Their Royal name low in the dust !
Their hapless race wild-wand'ring roam,
Tho' rigid law cries out, 'twas just ! "

BURNS.

---

Back to the index.


You think you have something to add to this article? You can do so by using this form below! Your comment will be added on the bottom of this page.

Name :
Type yellow text* :
Email** :
Comment :

*) To prevent abuse by automated systems we have to include this extra security step.
**) If you want to receive an email when a new comment is added, please include your email address here. Address will not be shown on this page or used for any other purposes.

On 17 October 2004, George Smith added the next comment:

I passed the maltings often when a schoolboy in the 40's and saw the malt being turned by hand. Later worked as Excise Officer (one of five) at what was then a grain distillery using a Coffey still. The cooperage was still very active in the 60's mainly remaking used American barrels of about 40 gallons capacity which arrived as flat packs. This and the other Lowland grain distilleries (5 was it?) produced as much spirit as the total of the malt distilleries. Now closed and rebuilt as housing I believe