DEVANHA DISTILLERY, ABERDEEN.

PROPRJETORS, wM. BLACK & Co.

ON entering the City of Aberdeen by the railway from the south, the attention is at once attracted by the Devanah Distillery, which, seen from the lofty bridge, bas a very imposing appearance. 1t is situated on the banks of the beautiful river Dec, within two miles of its confluence with the German Ocean, and nearly a mile distant from Aberdeen. The works, which have a frontage to the river of same 500 feet, are built principally of granite, and separated from the Dee by a splendid esplanade, which bas been recently constructed, and cast the city 1;95,000.

This Distillery, which was established many years ago, consists of two quadrangles, the main buildings of bath abutting on the railway.

Mr. Flockhart, the General manager, showed us over the place, We commenced at the sou th buildings facing the river, which are enclosed in a court yard, Passing through a gateway, we ascended an outside stone staircase to the top floor, which is one of the Barley'Barns, and is 150 feet long by 50 feet broad thence through an archway, shut of[ by a double pair of iron doors, into the left- hand angle of the building. This floor is 120 feet long and 60 feet broad, and the two Granaries are capable of holding 10,000 quarters of grain. The barley is lifted by an enclosed hoist outside the building, the wheel of which is attached to a wire rare stretching 200 yards over the roof to the steam-engine in the Distillery. The two floors underneath the first building we entered are concreted and used for.malting purposes; they possess two Steeps, each capable of wetting sixty quarters at a time. The basement of this building is used as a Bonded Warehouse. Under the Granary floor of the left angle are three other floors, all Bonded Warehouses. From the Maltings we passed into the Kiln, a lofty, building nearly 80 feet high and 36 feet square; it is floored with perforated iron plates, and peat, with a small ad mixture of coke, is used in the drying. The malt is raised by elevators to the Kiln floor. In the same building are the Malt Stores, immediately connected with the Kiln, capable of holding together 2,000 quarters. Under these stores there is a large shed filled with peat We next returned to the esplanade, and entered by a postern door into the Distillery proper. after inspecting the duty-paid Racking Store just inside the court, we mounted a stair to the balcony, which runs along in front of the Excise and Distillery offices. This balcony, which is reached at the other end by stone steps, overhangs the Worm Tub, which is stretched out before the office windows, like a small lake, and is nearly 100 feet long, i~ which are laid several hundred feet of worm coils. As we stood at the end of this terrace or balcony, we obtained a fine view of the river and its picturesque surroundings. But to return to thc process, the malt is brought from the Malt Deposit direct to the Mill in the enclosure, which place we next visited, where it is pulverized between a set of Malt-rollers, after which the grist is raised by elevators to the Hopper in the Refrigerator room, and from thence screwed away into a smaller receptacle over the Mash House. In this room, besides two of Miller's Refrigerators, there are two Worts Receivers and a large Heating Copper, and on Dur war down we passed other two Heating Coppers, supported on iron columns, and commanding the Mash-tuns below. When we reached the ground level we were taken to see the two separate Brewing Houses, each containing a Mash-tun, and no other vessel. The No. 1 vessel is 10 1/2 feet in diameter and 5 feet deep, and No. 2 ditto is 12 feet in diameter and 5 feet deep, each having connected therewith a Steel's Mashing Machine and the usual stirring ge ar. Our guide then conducted us down same stone steps to the two chambers underneath, each of which contains an Underback, holding 1,900 gallons, and made out of .the farmer Mash-tuns, which did duty in this. Distillery at the time of its foundation. From this stone chamber the worts are pumped up to the top of the building into the Refrigerators, and from thence by gravitation they run into the Wash- backs. There are a couple of Tun Rooms in this establishment, wherein are placed fourteen Washbacks, each holding 4,000 gallons.

Continuing our progress, we inspected the Engine House, which contains a 25-horse power horizontal engine and a steam boiler and pumps. At the end of an open path we come to the new Still House, a large and lofty building, concreted and well lighted. Here, on a gallery, is placed the Wash Charger. which commands the Stills, and holds 4,500 gallons. There are two Pot Stills- the Wash Still, which holds 3,300 gallons, and the Spirit Still, 2,800 gallons, a Low-wines and Feints Receiver, a Spirit Receiver, and the Safe. At the back of the Still House, enclosed by the high embankment of the railway, is the Spirit Store, wherein is a vat holding 6,000 gallons; the small paved yard in front is covered with empty casks, waiting to be filled. Distributed about the premises are four Bonded Warehouses.

We then retraced our war to the main entrance, and our guide conducted us to an old building which had escaped our notice, and adjoins the Brewer's residence. It is the old Distilling House, erected many years ago, and still used by the firm. It contains two Pot Stills of very ancient pattern ; one of them, a Wash Still, holds 2,315 gallons; the other, a Spirit Still holds 1,338 gallons, a Wash Charger, and two Receivers of similar capacity as the Stills also the Safe and Sampling Safe, &c.

Adjoining this building' there is a Carpenter's Shop, Cooperage, &c. Fire plugs are fixed all over the premises, and hand buckets on the Boors, which are always filled ready for use in case of fire. There are fine springs on the premises, but the water used in mashing comes from the City Waterworks, and the condensing water is pumped up from the Dee.

The Whisky made is from Malt only, and the annual output is 220,000 gallons.

The Bonded Stores can hold 6,000 hogsheads of Whisky, and are considered by the Excise same of the finest and best arranged Warehouses in the country.

Now but and ben the change-house fills,
Wi' yill-caup commentators;
Here's crying out for bakes and grills,
And there the pint-stoup clatters ;
While thick and thrang, and loud and lang,
Wi' logic and wi' scripture,
They raise a din, that in the end
Is like to breed a rupture
O' wrath that day.

Leeze me on drink, it gi'es us mair
Than either school or college:
It kindles wit, it waukens lair,
It pangs us fou o' knowledge.
Be't whisky gill, or penny weep,
Or ony stronger potion,
It never fails, on drinkin' deep,
To kittie up our notion
By night or day.

The lads an' lasses, blythly bent
To mind baith saul and body,
Sit round the table weel content,
An' steer about the toddy.
On this ane's and on that ane's look,
They're makin' observations;
While some are cozie i' the neuk,
And formin' assignations
To meet some day.
BURNS.

---

Back to the index.


You think you have something to add to this article? You can do so by using this form below! Your comment will be added on the bottom of this page.

Name :
Type yellow text* :
Email** :
Comment :

*) To prevent abuse by automated systems we have to include this extra security step.
**) If you want to receive an email when a new comment is added, please include your email address here. Address will not be shown on this page or used for any other purposes.

On 17 February 2005, Jaki Sinclair added the next comment:

The brewery has been totally demolished by Barratts at the beginning of February 2005, to make way for 80 flats. I am at Gray's School of Art and my whole final year degree show is centred on this site. A forgotten, neglected place minutes from the town centre of Aberdeen.

On 17 February 2005, Jeroen added the next comment:

Sad to hear how piece by piece this industrial past of Scotland is dissapearing. Not too long ago Littlemill was burned to the ground... And they had plans to resurrect that distillery... Sad...

On 31 October 2006, Lynne Lawrence added the next comment:

Does anyone have any photographs of the Distillery as it used to stand? Looking for photos for a birthday present?

On 31 October 2006, Jeroen added the next comment:

Not me Lynne, sorry.